By Rajan Philips –
In an artful move that has wrongfooted its critics, the NPP government would seem to have orchestrated the resignation of Energy Minister Kumara Jayakody and Ministry Secretary Udayanga Hemapala, while simultaneously appointing a Special Presidential Commission of Inquiry to investigate whether any irregularities or unlawful actions have taken place in the business of importing coal for the Lak Vijaya power station, by the state-owned Lanka Coal Company (Private) Limited. The Lanka Coal Company (LCC) had been created as early as 2008 under the Companies Act, following a cabinet decision in 2006, for the stated purpose of importing coal for power generation not only at Lak Vijaya, but also other potential thermal power stations. The presidential COI could technically cover the entire lifespan of the LCC.
While the usual busybodies are busy raking the NPP government over substandard coal brought from South Africa by an Indian supplier who had not paid the full registration fee on time, the focus should really be on the performance of the LCC from its inception to the current sensation. The sole reason for the LCC’s being is to bring home about 40 +/- shiploads of coal that (at 60,000 Metric Tonnes of coal per shipload) for a total of approximately 2.25 million MT – the amount of coal that Lak Vijaya requires for burning in one year to generate power at the full 900MW installed capacity.
Because of Lak Vijaya’s location on the west coast, at Norochcholai, in the Puttalam District, without a proper harbour facility, the shipment is restricted to the six/seven-month non-monsoonal period – from September/October in one year to March/April the next. 40 +/- shiploads over six/seven months work out to six or seven ships a month. So, the company has the luxury of the other six/seven months (March/April to September/October) every year to plan, procure and deliver 2.25 million MT of coal to Lak Vijaya, at competitive prices and to the required quality standards. Remember, it is not uranium we are importing, but coal. For one whole company that should be a QED (quite easily done) job – you would think. On the contrary, it has hardly been a QED.
The first question that comes to mind is whether a whole company is needed to arrange six to seven shiploads of coal a month for six months of the year. Now that a Presidential Commission of Inquiry (COI) has been set up, it would be interesting to see whether the Commission would also look into the reasons why the cabinet of ministers in 2006 decided to establish a new company for shipping coal. This was five years before the first phase of Lak Vijaya power generation was completed in 2011 at one third (300MW) capacity, with full (900MW) generative capacity reached three years later in 2014. The construction of Lak Vijaya had begun in 2006 and the LCC was created in 2007.
The country is familiar with all the construction delays and post construction problems of the storied power plant, but all the delays at the power plant should have given the LCC time to plan and put in place a streamlined mechanism for supplying coal. That has not been the case at all. That leads to other obvious questions – which are really about missing information regarding the sourcing and procurement of coal and ensuring its quality.
Sourcing and Procuring
First sourcing. It is generally known that the LCC has been importing coal from Australia, Indonesia, Russia – the world’s top three coal exporters, as well as South Africa. But there is no information on a supplier’s association with a particular country-source or the implications of switching from one country-source to another depending on the selection of a supplier. This information is not presented either in company documents (provided on its website and two annual reports (2017 & 2020) that are online) or in the audit reports including the most recent one which is also the most extensive one. As well, there is no source comparison by price or by quality – especially for the critical heating or calorific value, which is considered a “rank parameter” in quality evaluation of coal, and is fundamental to using coal in thermal power generation.
The second question or missing piece of information is about procurement. Every January, if I am not mistaken, the LCC calls for registration of suppliers based on past procurement experience, including conformance with quality standards, and corporate business performance. The LCC publishes the “Standard Values for Coal” for each year, which include the Gross Calorific Value (GCV, usually greater than 6,150 kcal/kg), moisture and material percentage contents, and grain sizes. These requirements are based on the manufacturer’s specifications, as they should be.
Registration applications are reviewed and approved for registration by cabinet-appointed committees mostly made up of senior CEB and relevant Ministry officials, and LCC and Lak Vijaya representatives. What is not available is a historical record of registered suppliers, their quality history, and changes over time. This record could also include bid takers from among the registered suppliers, tender details and prices, and selected suppliers. The absence of such record and trend analysis would likely have been a factor in creating opportunities for alleged fraud, preferential selections and the compromising of quality standards.
The third question and concern is about the quality of imported coal, especially the minimum calorific value for efficient operation of the turbines. Far more than the other two, the quality issue has been front and centre in all the news about coal over the years, and it became the subject of some detailed analysis in the April 2026 Special Audit Report on Coal Procurement.
For the 2025/2026 coal supply, 26 registered suppliers were invited to bid on 18 August 2025, 11 of them responded, and their bids were opened on 15 September 2025. Quite a short window. Of the 11 bidders, only two had previously supplied coal exceeding the rejection threshold of 5,900 kcal/kg GCV; eight of them had both exceeded and fallen short of the threshold in their previous supplies; one did not exceed the threshold at all; and the last one did not provide any GCV information. The tender was awarded to Trident Chemphar Limited of India, whose past GCV record indicates supplying nearly 300,000MT of coal exceeding 5,900 GCV, and twice as much, nearly 600,000MT, under 5,900 GCV.
As noted in the Special Audit Report, Trident had not paid the full registration fee of $5,000 when bids were sent out on 18 August 2025 and should not have a received the invitation to bid. However, the LCC would seem to have found a way to have the tender documents sent to Trident, accept Trident’s late payment of the balance due of the registration fee, and have its registration ratified four days later on 22 August 2025. As the Audit Report has correctly observed, this was a violation of the principle of fairness in procurement, especially involving competitive bidding on a tender of substantial value.
Heat Quality and Testing
As I noted earlier, the LPP’s “Standard Values for Coal” stipulates a GCV (Gross Calorific Value) greater than 6,150 kcal/kg). A lower value of 5,900 kcal/kg is used as the benchmark to reject coal loads that fall below that value. In other words, the practice has been to use 6,150 kcal/kg as the quality standard for supply, rejecting loads that come under 5,900 kcal/kg, and making price adjustments for loads with GCV that fall between the two values. Lowering the tender threshold to 5,900 opens the door for accepting supplies under what (5,900) was earlier the rejection threshold as the new normal.
The lowering of the quality requirement before and after an apparent cabinet authorization came into effect 23 June 2023 apparently after a cabinet decision. Before June 2023, eligible suppliers should have supplied a minimum of one million MT in the previous 36 months, of which at least 50% (500,000 MT) should have equaled or exceeded the rejection threshold of 5,900 GCV. After June 2023, the business turnover was reduced from one million to half a million metric tonnes, and the quality amount was reduced from 500,000 MT to 100,000 MT. These changes came home to roost in the procurement of coal for the 2025/2026 period under the new (NPP) government.
As I have noted, the selected supplier, Trident Chemphar Limited of India, did not have a good record for heat quality supply, the company’s 36-month record indicating only one third of its supply exceeded the 5,900 GCV requirement. But it was still higher than the new, but lower, standard of a supply record of 100,000 MT exceeding 5,900 GCV. But worse was yet to come.
The Trident tender provides for only 1.5 million MT of coal and of the 2.32 million MT of coal required for 2025/2026. To procure the balance and to add redundancy to the main Trident supply (which is rather puzzling), the LCC initiated a second tender in January 2026 – interestingly, not for the full 800,000 MT balance, but only 300,000 MT of it. And the second competitive tender following all proper evaluation was awarded to Taranjot Resources (Pvt) Limited, also of India. Taranjot was one of the unsuccessful bidders in the August-September 2025 tender and had the distinction of being the only one who had recorded an entire 36-month supply of coal (100% of 1.1 million MT) under 5,900 GCV. Go Figure!
The price comparisons are also revealing. Trident’s price is $98.5 CFR per MT for a total price of $148 million (SLR 45 billion) for supplying 1.5 million MT of coal. Taranjot’s price for supplying 300,000 MT of coal is $142 CFR per MT for a total price of $42.6 million (SLR 13 billion). For comparison, Taranjot’s unit price was $105 CFR per MT, three months earlier, in the main tender that was awarded to Trident.
Inexplicable as it is, this fixation to switch between term tenders and spot tenders has been demonstrated by the Lanka Coal Company from the time it started procuring coal for Lak Vijaya. The reasons for this are another matter that the Presidential COI will hopefully look into. Of the 465 coal shipments from July 2010 to March 2026, 135 have been procured through spot tenders.
To make matters worse, Trident’s actual supply turned out to be worse than its tender. The Special Audit Report provides the results of the quality tests on the coal that was supplied by Trident in its first nine shipments before 17 February 2026. There were three categories of tests performed over nine criteria, including the Gross Calorific Value (GCV) on samples taken from each shipment of coal – first at the Port of Loading, the Richards Bay Coal Terminal in South Africa, second at the Port of Discharge, and third in the Lak Vijaya Laboratory – both in Puttalam, Sri Lanka.
The Port of Loading tests showed far better results on each criterion for each of the nine shipments than the Port of Discharge tests and the Laboratory tests. Specific to the GCV heat criterion, the South African tests showed the coal in seven of the nine shipments exceeded the standard value of 6,150 kcal/kg; one of them registered 6,053, just under standard value; and the other at 5,904, just above the rejection threshold. The discharge point tests in Sri Lanka showed none of the shipments meeting or exceeding the standard value (6,150), with only two exceeding 6,000 kcal/kg. The Laboratory test results were the worst, with every one of the nine shipments registering below the rejection threshold of 5,900 kcal/kg, with five of them between 5,000 and 5,500 kcal/kg, and the other four between 4,500 and 5,000 kcal/kg.
The discrepancies in the results should not be surprising given the rather shoddy arrangements for testing at the South African end. Although testing at the source is the supplier’s responsibility subject to LCC’s approval, it is reasonable to expect that after about 15 years in this business the LCC would have set up a pool of accredited testing agencies that it could draw from for each tender. The test agent, or a pool of them, should be identified in the tender to avoid shopping around after the award.
The Special Audit Report includes extensive calculations of the energy (kilowatt-hour) and cost implications of using low calorific coal. The calculations are based on a comparison with the supply of coal between 2020 and 2025. There were 194 shipments during that period, and all of them exceeded 6,000 kcal/kg GCV, with 139 out of 194 (72%) exceeding the standard value requirement of 6,150 kcal/kg. The country-sources of these shipments are not known, and there is no information about the tests conducted on samples from these shipments, including the consistency or discrepancy between test results from the three testing locations. Curiously, this period includes the 2023/2024/2025 years which came after the June 2023 changes in quality standards, but shipments in this period do not seem to have been adversely impacted by the June 2023 changes. This overlap is not identified or noted in the Audit Report.
The Report indicates that the average consumption of coal in the 2020-2025 period was 375 grams per kwh, in comparison to the higher average consumption rate of 444 gm/kwh estimated for the coal supplied by Trident, based on coal consumption and power generation information from Lak Vijaya operators. The use of lower calorific coal triggers excessive coal consumption, inefficient power generation, and the need for alternative energy sources to compensate for the shortfall in coal power generation. The Audit Report estimates the cost of excessive coal consumption associated with Trident’s nine shipments to be SLR 2.24 million. At the same time, the supply agreement includes penalty for non-compliance which is estimated to be SLR 2.32 million. These estimates are useful indicators of the order of magnitude of losses when tenders go wrong. But they will be vigorously challenged if penalties are imposed or contract is terminated.
The current low calorific coal fiasco is not the first instance of tender sloppiness involving the Lanka Coal Company. There have been allegations of fraud when coal was purchased from Australia. In 2014, there was another controversy when after selecting a Singapore shipping company for supplying coal from Indonesia, the tender was altered to include a port of origin in Russia. In 2016, the Supreme Court declared a coal supply tender null and void and ordered it to be superseded by a new tender call. In 2017, then Minister of Power and Renewable Energy, Ranjith Siyambalapitiya, dissolved the entire LCC Board of Directors, over procurement malpractices between 2009 and 2016. In 2022, a fundamental rights petition was filed in the Supreme Court over alleged misappropriations in coal procurement.
It is true the NPP did inherit a mess, but the government also had enough time to review and rectify the tender process, to eliminate malpractices and live up to its own promises. With an Electrical Engineer as Minister and an Electrical Engineering Professor as Ministry Secretary, the government had technical literacy at the highest level and should have been alert to the shortcomings in the coal procurement and quality control processes. The country should and could have been spared all the tender controversies, the police sealing of LCC offices, high profile resignations and, most of all, another crisis in power supply.